2013 Volvo S60

2013 Volvo S60 recalls (4)

• AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

  Volvo is recalling certain model year 2013 S60 and XC60 vehicles. A manufacturing defect within the Supplemental Restraint System (SRS) control unit may lead to an inadvertent deployment of the seat belt pretensioner and/or inflatable curtain.

  Remedy: These vehicles have not been sold and the SRS control unit will be replaced prior to the cars being sold. Owners may contact Volvo at 1-800-458-1552.

• EQUIPMENT:OTHER:LABELS

  Volvo is recalling certain model year 2013 S60 and XC60 vehicles, manufactured on January 7, 2013. The product identification labels were printed with the incorrect manufacture year. Thus, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification Regulation."

  Remedy: Volvo has quarantined the affected vehicles and will install correct labels prior to sale. The recall began during March 2013. Owner notification letters will not be sent.

• SEAT BELTS:FRONT

  Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.

  Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.

• LATCHES/LOCKS/LINKAGES:DOORS:LATCH

  Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.

  Remedy: Volvo will notify owners, and dealers will replace all four door latches, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89978.

2013 Volvo S60 safety ratings

Source: NHTSA NCAP ratings.

2013 Volvo S60 owner complaints (15)

• ELECTRICAL SYSTEM

  The “Tire Pressure System” warning appeared and has not turned off. New TPMS sensors were installed but the dealership could not get the car to calibrate despite multiple attempts. It has come to my attention that other models of Volvo have this same trouble, and a software update is required.

• UNKNOWN OR OTHER

  In 2023, the engine of my 2013 Volvo S60 failed completely without prior warning and the vehicle had to be scrapped. Before that, in 2022, I paid $1,500 for a full front-end suspension rebuild due to abnormal wear. These failures were later determined to be consistent with high mileage. I had purchased the vehicle in 2019 believing it had 85,125 miles, but a 2025 VINinspect report based on NMVTIS data revealed the true mileage at sale was over 137,000 — a rollback of more than 50,000 miles. The title is now branded “Not Actual Mileage” by the federal database. This odometer fraud misled me into driving a severely worn vehicle that could have posed a serious safety risk, especially once the engine failed unexpectedly. No warning lights appeared prior to failure, and the engine is no longer available for inspection as the vehicle was sold for scrap. Independent mechanics noted the level of wear was not consistent with the mileage shown at the time of purchase. I have reported this case to NHTSA, the NY DMV, FTC, Attorney General, BBB, and others

• STEERING,POWER TRAIN,ENGINE

  I am submitting this report to formally document a severe safety-related failure involving my 2013 Volvo S60, VIN # [XXX] . This vehicle is part of the Volvo brand, widely recognized and marketed as among the safest in the world. Incident Summary: On [XXX], at approximately [XXX] in Norwalk, Connecticut, the vehicle experienced a catastrophic mechanical failure while in operation. The auxiliary (serpentine) belt suddenly failed, shredded itself, and wrapped around the timing pulley. Debris from the failed belt entered the timing belt housing — a supposedly sealed and protected compartment — causing the timing belt to jump. This resulted in an immediate loss of engine power while driving, placing me in a highly vulnerable position. Fortunately, I was not on a multi-lane highway or in fast-moving traffic. Had I been traveling on a busier route, the sudden loss of power could have led to a serious crash and potential injury. This failure represented a genuine threat to my safety. Further inspection revealed that: The lower crankshaft sprocket had skipped three teeth due to the intrusion of the auxiliary belt. The timing belt, although not broken, was off track. A new timing belt was installed in an attempt to restart the engine. The engine would crank but failed to start. A compression test revealed zero compression in all cylinders. The valve train was severely damaged (bent valves), and the engine sustained internal mechanical failure beyond repair. Conclusion and Context: This is not an isolated incident. Upon further research, I discovered that this failure — specifically the auxiliary belt disintegrating and compromising the timing belt system — is a known and well-documented problem in vehicles equipped with the B5254T12 Turbo engine. Volvo has been previously alerted to similar cases before. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ENGINE

  Engine has excessive oil consumption and sets owners up for expensive testing and repairs, because when the original recall came out, many Volvo s60 with excessive oil consumption were barely out of the allowed mileage range, which sticks the owners with excessive repairs. Volvo should stand behind this problem that effects numerous Volvo s60’s and compensate the repairs.

• VISIBILITY/WIPER

  Since we purchased the car in December, water was observed on occasion streaking down the inside of the windshield. The headliner is damp after rain, and is stained from water as a result. Additionally defrost/defog wasn’t working, and my son reported having to pull over and wait for the rain to stop so he could drive with the windows down in order to be able to see the road. INCREDIBLY unsafe/unable to drive in the rain. I recently applied pressure to the inside of the windshield with my fingertips by the A-pillars on both driver and passenger side to test the seal and visually confirmed the windshield was lifting off of the frame, revealing a broken seal along the top and sides of the windshield.

• ENGINE

  car has high oil consumption. takes a full oil change every month

• EXTERIOR LIGHTING

  Vehicle was off in driveway and fire started from right rear taillight. Fire extinguished via fire extinguisher after 5 minutes but car totaled. Inspection by fire department indicated source of fire was right rear tail light.

• ENGINE

  I currently own a 2013 S60 2.5L T5 sedan (See Vin # referenced in Subject Line) that recently began displaying on the DIC the following alert/error messages: •Low Oil/No Oil Pressure alert My vehicle only has 67,400 miles on the engine and I am the 2nd owner of the vehicle purchasing it with only 19,560 miles or so, approximately 3.2 yrs ago. Due to my distance from home to the nearest authorized local Volvo dealership (Manasquan NJ), when this warning came up on the car, I immediately took it to an authorized ASE local service repair shop. This vehicle’s oil has always been changed within Volvo manufacturer recommended oil change intervals, so I know that was not a potential cause. I did check the oil level, which was low and there has been no visible under the vehicle oil puddles/stains prior to taking it to determine the root cause of the alert. While at the local service repair center, I was alerted by the service manager that for this year model, there is a known manufacturing issue related to defective O-rings and Pistons causing the vehicle to heavily consume oil, potentially leading to engine failure and poses and immediate safety risk to myself and family members as well as the driving public if there was to be an engine failure. I reached out to Volvo USA earlier today to express my dismay and shock that for one I was not notified of this potential safety recall. I was then to my chagrin informed that my vehicle was not involved/eligible for an extended warranty coverage in an earlier settlement that Volvo was involved in, but also to my surprise I came across a Class Action lawsuit filed against Volvo for deceptive practices related concealing prior knowledge of this safety defect related to the O-Rings and Pistons. (See attached docs for settled Lawsuit Action and an earlier issued Quality Bulletin-[XXX]: Issue Date 1-04-23). After reviewing these two documents, it is clear to me that the bulletin deployed as well as the settling of the NJDCA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ENGINE

  The engine has started to burn excess oil prompting the service engine light to come up way before next oil change. Auto mechanic has to add 5 quarts oil between oil changes on regular basis now telling us the Dealership will need to address the issue. Suggested we replace O rings in engine which is costly repair with no guarantee will solve issue. Could not afford the expensive repair. Recent online research shows this is common issue in the S60 between 50k-100k miles. I Bought this car for daughter as it had every service check required and thinking it was safe reliable car but now risk her running out of oil and engine stop working. 2013 S60 with 90k miles should not have engine problems, especially a Volvo known for high quality. Disappointed that reburbished engine not offered. I am loyal to Volvo having had 2 previous ones but am not impressed with the servicing of this issue.

• UNKNOWN OR OTHER

  I was driving my 2013 Volvo S60 T5 when I felt a sudden, sharp pain in my hand and started bleeding. After safely stopping, I discovered that the chrome trim on the steering wheel had detached from the steering wheel itself and caused a minor cut on my finger. Upon further inspection, I found that the trim is secured to the steering wheel with an adhesive that deteriorates over time, and the trim itself has sharp metal edges.

• ENGINE

  The car consumes approx. 0,5 to 1,0 liters of oil per 1000 miles. The problem started around 60,000 miles and has slowly worsened. Volvo admits that there is a problem with the piston rings, and the only fix is an expensive oil consumption test followed by an engine teardown and rebuild

• ENGINE

  Received a notification from Volvo USA, acknowledging an excessive oil consumption problem with certain model from 2013 to 2016, our 2013 S60 being one of them. Apparently it is a known design problem relating to pistons/ring, which can potentially damage the engine. This notification stated that Volvo voluntarily extended the warranty to 8 years and 100,000 miles, which of course excluded our 2013 S60! How is it that Volvo can get away with this?? Should this not be a recall? There was a class action against Volvo on this specific problem, but was resolved outside of court. This means that a handful of owners got compensated, but there are a lot more of us out here, trying to figure what to do about this!!! Do we need to start another class action? The government should not let corporations like Volvo get away with this!!! Please do something about this!

• ENGINE

  Purchased the car with 120,000 miles and noticed it was burning 5 1/2 quarts of oil every 3,500 miles. Thought it was an oil leak and had that repaired but issue continued. Drove another 3,500 miles and had to add another 5 1/2 quarts of oil. Light never went on the last time and oil level was so low that engine now has rod knock. Only recourse is to replace the engine and I cannot afford the repair. Volvo acknowledged that these cars have excessive oil consumption issues but will only pay for repairs for cars less than 10 years old or have under 100,000 miles

• ENGINE

  Excessive oil consumption. Having to add ~5 quarts per month. Brought this to Volvo's attention in 2019 and had Volvo service confirm excessive oil consumption.

• ENGINE

  I own two 2013 S60 and both with excessive oil consumption. Having to add ~5 quarts per month. Brought this to Volvo's attention in 2019 and had Volvo service confirm excessive oil consumption.