2020 Toyota Tundra

2020 Toyota Tundra recalls (5)

• FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

  Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

• STEERING:HYDRAULIC POWER ASSIST SYSTEM

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

  Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

• EXTERIOR LIGHTING:HEADLIGHTS

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.

  Remedy: Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.

• EXTERIOR LIGHTING:TURN SIGNAL

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Remedy: Toyota will notify owners, and dealers will modify the wire harness connected to the front turn signal bulbs free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-800-270-9371. Toyota's number for this recall is 20TB12/20TA12.

• STEERING:HYDRAULIC POWER ASSIST SYSTEM

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

  Remedy: Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 21TH01.

2020 Toyota Tundra safety ratings

Source: NHTSA NCAP ratings.

2020 Toyota Tundra owner complaints (15)

• STEERING

  Steering is intermittently difficult, almost as if no power steering. Steering wheel does not return to center after a turn. There were no warning lamps or messages displayed on the vehicle. This is a safety issue in that it could an accident by not responding properly to driver input. Took vehicle to Toyota dealer who diagnosed problem as "Intermediate Steering Shaft Binding." Toyota dealer replaced steering intermediate shaft. Dealer kept old steering shaft.

• UNKNOWN OR OTHER

  In a 2020 Toyota Tundra, 1794 Edition (60k miles), traveling at normal highway speed, the moonroof glass panel spontaneously exploded. There was no previous damage or modification to the moonroof panel. Panel explosion was extremely loud and surprising. Large pieces of glass were blown back onto the highway. If the shade was not drawn at this time, large amounts of glass would have also rained down onto the driver and passenger of the vehicle. Clear dash camera footage shows speed under the speed limit, and no impact from any sort of debris.

• SEATS

  The contact owns a 2020 Toyota Tundra. The contact stated that while the vehicle was parked, the contact discovered that there was smoke inside the vehicle. The contact opened the front passenger side door and discovered that the front passenger seat was burned and had melted. The contact stated that the front passenger seat had caught on fire and extinguished itself prior to the contact discovering the smoke. The origin of the fire was from the front passenger’s heated seat function. No warning lights were illuminated. The vehicle was unoccupied during the fire. Neither a Fire nor a Police Report was filed. The vehicle remained at the residence. The dealer was contacted, and the contact was informed that the front passenger’s seat heater needed to be replaced. The vehicle was not repaired. The contact also mentioned that the insurance company declined coverage since they deemed it to be a manufacturer's defect. The manufacturer was notified of the failure. The failure mileage was unknown.

• STRUCTURE

  IN BACK CEILING LEAKING WORSE NOW...

• VISIBILITY

  The contact owns a 2020 Toyota Tundra. The contact stated that while opening the sunroof, the sunroof made an abnormal chainsaw sound. The message "Window Open" was displayed. The contact stated that the sunroof was opening and closing independently. The vehicle was taken to the local dealer, where it was diagnosed, and determined that the cables had seized, and the sunroof glass was stressed. The dealer linked the failure to Technical Service Bulletin: 004220. The contact stated that the window failed to close. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no warranty coverage or Goodwill assistance for the repair. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 46,000. The VIN was not available.

• STRUCTURE

  BODY TOP CELING IS LEAKING.. TOYOTA TRY TO COST ME OVER ONE THOUSAND I CANT AFFORD.. I SEE LOT OF COMMON RECALL FROM OLD TUNDRA HAVE SAME PROBLEM. I THINK TOYOTA IS RESPONBILE TO FIX...

• UNKNOWN OR OTHER

  It happend today .. I notice while I Cleaned .....back seat ceiling leaking . it seem come from third brake light it no recall on list..

• FORWARD COLLISION AVOIDANCE

  The contact owns a 2020 Toyota Tundra. The contact stated that on several occasions while driving at various speeds, the "Pre-Collision System Failure” warning light and icon were illuminated. Additionally, the message "See Dealer" was displayed. The contact also stated that the rear passenger’s side wheel locked up intermittently. The check engine warning light was illuminated. The vehicle was taken to the residence where the contact disconnected the battery, cleaned the cameras, and allowed the ECU to reset; however, the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 2,550.

• UNKNOWN OR OTHER

  Spontaneous explosion of sunroof, under normal driving status, pictures were taken, the toyota deealer has replaced and repaired at my cost, I have filed an insurance claim with USAA and uploaded bill and pictures, The shattered glass could have entered the cab but did not. No warning lights or other symptoms appeared before the incident.

• STRUCTURE

  The sunroof shattered while driving down the freeway. No vehicles near or overpasses near. The shade was closed so the glass fell on it not on my head or passengers that could have been present. Sounded like a loud pop. Then I heard wind noise. The glass is blown upward, not downward. I am 40 year auto technician and own my own shop. Its my personal truck I bought new. Has never had any issues at all. This is a defect of some sort. My thought is, since I never use it. The seals aroung the glass bound in the roof opening, thus binding it where it finally flexed and shattered.

• FUEL SYSTEM, GASOLINE

  The contact owns a 2020 Toyota Tundra. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine and traction control warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 34,000.

• UNKNOWN OR OTHER

  Driving on the highway and the sunroof spontaneously exploded — portions of glass traveling up and out of the vehicle, with some falling into the sunshade. Skies were clear with temperatures around 25 degrees Fahrenheit. There were no overpasses or other structure from which debris could have fallen, nor could it have come from another vehicle.

• SERVICE BRAKES

  I was driving in a 25 MPH zone approaching a red light preparing to stop. I had increased the pressure on my brake pedal and then my foot slipped of the pedal just seconds before I ran into a truck that was stopped at the red light. After further investigation I found out that the brake pedal pad has been substituted by Toyota Manufacturing. My 2020 Tundra was purchased new and has 8,800 miles on it. The petal pad is made from a PVC plastic material as stated on the bottom of the pad. There are no part #s on the pad which is suspicious that this is not a Toyota pad. The PVC material is very slippery, especially if the surface was wet. Come to find out that my 2023 RX 350 has the same brake pad. Both of these pedal pads will be replaced immediately from Toyota. Please Note. I could not upload any of the documents that you had requested. Something is corrupted with the web page that asks for upload files??????

• FUEL/PROPULSION SYSTEM

  Can not fuel truck normally. Gas stops pumping after 2secs and have confirmed the issues with multiple gas stations.

• ELECTRICAL SYSTEM,UNKNOWN OR OTHER

  NOTE: Toyota has confirmed this issue, but is unable to resolve this. When the SOS button is pressed, the DCM module is supposed to send the proper VIN number and location to the call center. The call center does not receive the proper VIN number and pulls up the wrong person / location. In my case, if an emergency occurred, they would send emergency assistance to a vehicle located in another state entirely. This is not because the wrong owner is assigned to their system. They can find my vehicle VIN with the proper owner information in their system. The issue is that the DCM module (or other system) is actually sending the wrong VIN to their system. The Toyota SOS call center says to see the dealer and the dealer says they are unable to fix this. If this is not isolated to just my vehicle, this could cause a loss of life if emergency assistance never arrives at the proper vehicle location.