2016 Toyota Tacoma

2016 Toyota Tacoma recalls (4)

• STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2011-2016 Toyota Tacoma and 4Runner vehicles equipped with accessory hood scoops installed by SET or SET dealers. The adhesive attaching the hood scoop may weaken, allowing the hood scoop to detach from the vehicle.

  Remedy: SET will notify owners, and dealers will mechanically fasten the scoop to the hood, free of charge. The recall began on September 1, 2017. Owners may contact SET customer service at 1-954-429-2000. SET's number for this recall is SET17B.

• ENGINE

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles equipped with a six-cylinder engine. The affected vehicles have a crank position sensor that may malfunction, potentially resulting in an engine stall.

  Remedy: Toyota will notify owners, and dealers will replace the crank position sensor with an improved design, free of charge. The recall began July 26, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0H.

• POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2017 Tacoma vehicles. Oil may leak from the area where the rear differential carrier is assembled to rear axle housing.

  Remedy: Toyota will notify owners, and dealers will inspect the rear differential for oil leakage. Based on the inspection, dealers will either tightening the fastening nuts or replace the fastening nuts and gasket. If the rear differential components are damaged, the rear differential carrier assembly will be replaced. The repairs will be performed free of charge. The recall June 19, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0G.

• AIR BAGS:KNEE BOLSTER

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Tacoma trucks manufactured August 20, 2015, to September 10, 2015. In the affected vehicles, incorrect bolts were used to install the driver's knee air bag module.

  Remedy: Toyota will notify owners, and dealers will install the correct driver's knee air bag module mounting bolts, free of charge. The recall began on November 19, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is F0T.

2016 Toyota Tacoma safety ratings

Source: NHTSA NCAP ratings.

2016 Toyota Tacoma owner complaints (15)

• POWER TRAIN

  The contact owns a 2024 Ford Edge. The contact stated that the vehicle was shaking while driving. The contact noticed there was fluid emerging from the rear of the vehicle near the tire. There were no warning lights illuminated. The vehicle was taken to the local dealer, who confirmed there was no recall or leak. The vehicle was not repaired. The manufacturer was contacted, who referred to the local dealer. The failure mileage was approximately 100,000.

• FUEL/PROPULSION SYSTEM

  The original low pressure fuel pump failed at 114,700 miles. The symptoms of the failure were loss of power on the freeway, quickly followed by the engine stumbling, then shutting off completely forcing me to change lanes without power. The vehicles has had to be towed on 2 occasions because of this. The pump was replaced at 114,700 miles by a Toyota dealer at my own cost (no warranty, no recall). Now only 20k miles later the fuel pump has failed again. This issue has put my family at serious risk of accident to complete engine shut off at highway speeds. Now that I am on my third low pressure fuel pump, I have little confidence that this is being addressed by the pump manuf. and Toyota.

• SEAT BELTS,SEATS,UNKNOWN OR OTHER

  Dear Toyota Japan Customer Experience Team, I am the owner of a 2016 Toyota Tacoma currently registered in Guam, U.S.A. I am writing to request your assistance regarding a water leak issue from the rear brake light area, which has caused the carpets and seats to become wet and develop mold. I originally purchased this vehicle in Saipan and recently relocated to Guam. When I visited the Guam Toyota Service Center, they kindly inspected my vehicle and informed me that this issue is related to the 3rd brake light gasket recall; however, the recall period has already expired. Unfortunately, I was never notified of this recall while the vehicle was in Saipan. Continuous exposure to mold has seriously affected both my health and my daughter’s health. Because of this, I had the vehicle professionally cleaned and sanitized by a specialist company. The Tacoma has always been our family’s favorite car, but now I drive it only because I have no choice. Every time I get in, I feel anxious and uneasy. The water leak itself is concerning, but the mold issue worries me even more. I truly hope this water leak and the mold problem can both be resolved so that I can once again enjoy driving my Tacoma with peace of mind. The blue circles in the attached photos indicate areas suspected of mold. These photos were taken right before I sent the car for cleaning. According to the cleaning company, when they removed the seats, they found water underneath the seats and carpets. Whenever I drive the vehicle, I experience persistent coughing and headaches due to mold exposure. This has become a serious health and safety concern. Since this issue is directly related to a previously recalled safety defect, I kindly request Toyota Japan to consider a Goodwill Repair or Safety Exception to address the water leak and the resulting interior damage.

• STRUCTURE

  Severe clear coat and paint fading on hood, roof and sides of truck.

• POWER TRAIN

  2016 Toyota Tacoma is known to have an issue with the timing cover leaking oil. This is a Fire Hazard: Oil leaking onto hot engine components can vaporize and ignite, posing a fire risk to the vehicle and surrounding areas and can cause environmental pollution.

• LATCHES/LOCKS/LINKAGES

  The rear passenger door lock actuator on my 2016 Toyota Tacoma failed prematurely, causing the door to no longer lock or unlock properly. The failure required replacement of the entire actuator assembly at a Toyota dealership at a cost of $727.19. This failure occurred without abuse or unusual use and is not consistent with normal wear and tear. I am aware of numerous similar complaints and pending class action lawsuits involving door lock actuator failures across multiple Toyota models, indicating this is a known and recurring defect. A door that cannot reliably lock or unlock presents a safety and security concern, particularly for passengers and children, and increases the risk of unauthorized entry or inability to exit the vehicle in an emergency.

• STRUCTURE

  2016 Toyota Tacoma – severe clear coat and paint failure on the hood and roof. The clear coat began peeling in 2022 and has progressively worsened. Large sections of the hood and roof show complete delamination, oxidation, and exposed basecoat. This is a widely reported defect for 2015–2017 Tacomas across multiple paint colors. Toyota Customer Care confirmed today that my VIN is not included in Customer Support Program 23TE08 and that no goodwill repair would be authorized, even though the defect is identical to the vehicles Toyota acknowledges as affected. This appears to be a manufacturing defect that compromises durability and corrosion resistance. Photos and documentation are available upon request.

• STRUCTURE

  Paint on hood and roof is fading significantly.

• UNKNOWN OR OTHER

  The seat heater pins have melted, leaving black residue. thus showing possibilities of a fire

• STRUCTURE

  The contact owns a 2016 Toyota Tacoma. The contact stated that while driving, there was a musty odor coming from the interior of the vehicle. The contact was unable to locate the source of the odor. The contact stated that on a separate occasion, while vacuuming the vehicle, the contact noticed that the carpet and floor mats from the rear passenger’s side were wet. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear quarter duct vents had fractured, and water was entering the interior of the vehicle. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 80,000.

• ENGINE

  Bought 2016 Tacoma in 2022 w/ 53k miles. Hit 58,850 (ish) and had an noticable oil leak… apparently this was a “Well Known” issue, as the mechanic @ Surprise, AZ Dealership (Toyota of Surprise, 13543 N. Auto Show Ave., Surprise, AZ 85388) told my wife and I…. it’s from this same thing that google showed me also: “Engine oil leaks: Reports on Consumer Reports and other forums detail expensive repairs to fix oil leaks from the front seal or timing cover, which can cost $5,000 or more because the engine often needs to be removed for the repair.” And this was 100% my case- and confirmed by the Toyota Dealers Mechanic verbally. Leaks were without engine light indicators “at all”. The dealership added a dye, told me to drive 100-500 miles and return to have a re-inspection done after their initial one came with no results. Initially I spotted this while I was conducting a regular 3,000 mile oil change. (2nd oil change since owning the truck. So my out of pocket was around $5,700+, for an apparent (see attached) “well-known” Dealer issue. @ 60k, a major repair cost for this should NOT but coming from the consumer, and needs to be listed as a “recall”. Had I not noticed the missing oil, this could have left me stranded, my family stranded, or caused many other traveling issues throughout my driving experiences. I repaired this around two years ago, but have been terrified to drive my truck! I’ve driven about 1,000 miles or less since the repair (in 2 years time). I’m selling first chance I can, BUT, I WANT MY MONEY BACK! I have the receipt in a safe for when this becomes a recall - to prove i paid it, and to get a FULL REFUND!!! That is not how good business is done by Toyota. I owned a 2004 and 2005 Camrys prior, as well as a 2014 Lexus GS 350 F Sport (all in my name), this truck was a dream, now a nightmare. Please, for everyone complaining online and those that have had to also pay for these repairs @ low mileage, MAKE THIS INTO A RECALL FOR 2016 TACOMAs.

• ELECTRICAL SYSTEM

  I am reporting a persistent and unsafe issue with the factory-installed Entune infotainment system in my 2016 Toyota Tacoma. While driving — whether locally or on the highway — the system frequently freezes, becomes unresponsive, or abruptly resets itself, often multiple times per drive. This directly affects my ability to safely use the navigation, backup camera, and audio controls while in motion. The system’s crashes divert my attention from the road, especially when I’m relying on navigation and it either stops functioning or forces me to interact with the screen to regain control. These interruptions increase the risk of distracted driving and could easily contribute to an accident. I have attempted to install the software update provided on Toyota’s official website, but the update is older than the version already installed on my vehicle (0101A0), so the system blocks the update. There is no way for a consumer to reinstall or flash the current version, and any potential resolution is only available at a dealership for a fee, effectively putting the fix behind a paywall. Toyota has not issued a recall or service bulletin for this issue, despite dozens of reports from other owners on Tacoma and Prius forums describing the same crash behavior and software version conflicts. This is a significant safety concern, especially when the infotainment system is used for navigation during high-speed or complex driving conditions. The inability to maintain consistent functionality puts drivers and others on the road at risk. I am requesting that NHTSA investigate this widespread issue and press Toyota to issue a free repair or software patch for all affected vehicles. Symptoms: •Frequent infotainment restarts while driving •Frozen or unresponsive touchscreen •Glitched navigation system and lost GPS routing •Driver distraction due to repeated system failure

• ENGINE

  I have experienced two major failures on my 2016 Toyota Tacoma TRD Sport with less than 90,000 miles: a leaking coolant crossover pipe, which required partial engine disassembly and cost me approximately $2,500, and a leaking timing chain cover, which required a full front-end teardown and cost over $4,500. Both issues are known problems across 2016+ Tacoma models with the 3.5L V6 (2GR-FKS engine), yet Toyota has not issued a recall or warranty enhancement. These failures present safety risks related to overheating and oil loss and result in significant financial burden to owners. Toyota needs to be held accountable for these premature, design-related failures.

• STEERING

  During a safety inspection, it was found out that the steering rack was leaking. In a quick research on Google, it appears that many people that own this particular year and tacomas are experiencing the same issue. It is the first time for any car that we own and we keep our cars for more than 10 years. To us, this could be a manufacturing defect that should be investigated and a recall issue. We had it fixed so it can pass inspection, but something just doesn't make sense.

• SUSPENSION

  When using four-wheel drive, the vehicle was unable to make a left turn. I disengaged four-wheel drive, and the vehicle was stuck in four-wheel drive. This happened on two occasions. The first time was approximately August 2022 and the second time was last year. When I took it to the dealership, they said here was nothing wrong with it and they told me that I probably used the four-wheel drive incorrectly. Luckily, I was able to get the truck into a parking lot. The way that I was able to disengage it was to put the truck into reverse and back up a few yards then go forward a few yards and repeat until I hear a loud thump.