2010 Toyota Highlander

2010 Toyota Highlander recalls (10)

• SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

  Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

• SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

  Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

  Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

• AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

  Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

• VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

  Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

• AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

  Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

  Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

• EQUIPMENT:OTHER:LABELS

  Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

  Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

• EQUIPMENT:OTHER:LABELS

  GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

  Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

• EQUIPMENT:OTHER:LABELS

  SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

  Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

• VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).

  Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

• VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

  TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

  Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

2010 Toyota Highlander safety ratings

Source: NHTSA NCAP ratings.

2010 Toyota Highlander owner complaints (15)

• FUEL/PROPULSION SYSTEM

  My car all of a sudden went into limp mode while driving on the 91 freeway with my kids in the car on may 21 2026. It had master warning ️ light and check engine light and a circle warning light that is the braking system also it said on the screen check hybrid system stop the vehicle in a safe place immediately and contact a dealer. It smelled like smoke as I was trying to get out of traffic and drive it to the shoulder.I towed the car to the Toyota dealer in Orange and was told it's the inverter and its fried and needs to be replaced.

• ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  When applying the brake slowly all of a sudden the car went full acceleration and crashed 500ft away at high speed. The car is crashed but available for inspection for a short period of time until the insurance company takes full posession. There are not open recalls. The only lights on the dash were for TPMS sensor.

• ELECTRICAL SYSTEM

  The contact owns a 2010 Toyota Highlander. The contact stated that the gear shifter had been stuck on several occasions. The vehicle was taken to the dealer, where the fuses were replaced on several occasions; however, the failure persisted. The vehicle was taken back to the dealer, where it was diagnosed and determined that the rearview mirror wiring had failed. The vehicle was repaired. The contact related the failure to an unknown recall. The manufacturer was not notified of the failure. The failure mileage was unknown.

• ELECTRICAL SYSTEM

  The contact owns a 2010 Toyota Highlander. The contact stated that while driving 40 MPH, the vehicle lost automotive power and started to drift to the right side of the road. The brake pedal was depressed, and the vehicle was able to come to a complete stop. The contact mentioned she waited for AAA for roadside assistance. The vehicle was towed to an independent mechanic, where it was diagnosed alternator needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure but offered no assistance. The failure mileage was approximately 185,420.

• EXTERIOR LIGHTING

  Headlamps become cloudy and burn out new, expensive bulbs in months. Internet search says Toyota is aware of problem, but prior to my search my dealership wanted to charge me hundreds of dollars to 'evaluate electrical system'

• SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  We received this from Toyota. Customer Support Program Bulletin Date: Page: POL19-06 6/6/2019 1 of 3 REVISED 8/28/19 CUSTOMER SUPPORT PROGRAM BULLETIN (ZKC): REPAIR COVERAGE FOR BRAKE ACTUATOR ASSEMBLY AND BRAKE BOOSTER PUMP ASSEMBLY ON CERTAIN 2008-2010 MY HIGHLANDER HYBRID VEHICLE. When we received this bulletin, we asked our Toyota Dealer Service Department (Stevenson Toyota East, Denver, CO) to address this issue multiple times when bringing in our vehicle for service in 2019 and 2020 and were told repeatedly they would not fix this issue since the ABS light was not on. Now that this bulletin is expired the ABS light is on. We took our Highlander to the Toyota Dealership in Melbourne, Florida and were told that this repair will now cost us $2473.89. Our 2010 Highlander is barely worth that, and now we have to repair this on our own even though Toyota knew the brake actuator assembly and brake booster pump would eventually fail at some point in time. Despite this, Toyota refused to resolve this issue when we asked (more than once) right after receiving the service bulletin in 2019 and as a result is causing a safety issue for our college aged son who drives this car, and all other drivers on the road should the ABS system fail. The attached estimate states the ABS service light has not come back on but this is not true and my son is having issues with the brakes.

• ENGINE

  The engine failed and locked up. Maintenance is completed every 3-4 months on schedule. There was no oil or water. Car was towed to a mechanic.

• SERVICE BRAKES

  When traveling a slow speeds (less than 15 mph) and needing to stop, the brakes are pressed but do not respond. This has happened on several occasions and has caused two separate accidents where the Highlander has failed to stop and it runs into the car in front. After the first accident, we looked for recalls (2015) and there were none for any model Toyota for brakes or brake systems. We brought the car in to the mechanic and had all the brakes and pads replaced, although they said nothing was wrong with the shoes nor pads. Now, years later, another accident in the exact same way. Luckily, due to the slow speed, no one was hurt but this is definitely a problem with the car. There have never been any warning lights, or sounds that would indicate an issue.

• SERVICE BRAKES

  Affected by the faulty Brake Actuator & Accumulator on 2010 Toyota Highlander Hybrid. Brake malfunction and ABS disabled lights popped up on my Multi-Information Display. This issue disables ABS & VSC systems, which therefore makes this a safety hazard. Upon doing research, I have concluded that many complaints about this specific "Brake actuator & accumulator" have been issued. In the past, Toyota has provided a "Customer Support Program" which expired in 2020, but this does not help current owners like myself, who are stuck with this problem.

• SERVICE BRAKES

  On approx. October 19, 2023 my vehicle started showing 4 error messages on the display: Brake Malfunction, Check ABS, Check VSC System, and Check Brake System. At the same time, these 5 warning lamps became illuminated: Brake System Warning Light and Warning Buzzer (Red), Brake System Warning Light (Yellow), Master Warning Light (Yellow), ABS Warning Light (Yellow), and SLIP Indicator (Yellow). A car repair technician obtained the following error codes from the vehicle in a diagnosis: C1391 (Abnormal Leak in Accumulator). I was informed that the VSC (vehicle stability control) safety feature of the vehicle is disabled while the error codes and messages are present. Toyota previously issued a customer support bulletin (No. POL19-06) on June 6, 2019, titled "Customer Support Program ZKC: Certain 2008-2010 Model Year Highlander Hybrid Vehicles Coverage for Brake Actuator Assembly and Brake Booster Pump Assembly". In the bulletin, Toyota acknowledged that its 2008-2010 Highlander Hybrid models had "certain internal malfunctions of the Brake Actuator Assembly". Affected error codes include C1391 and C1253, among others. Affected warning lamps consists of all 5 of the warning lamps that were illuminated in my vehicle. Affected parts include 04008-26448 (Actuator Assy, Brake w/ Fluid) and 04008-51148 (Pump Kit, Brake Booster w/ Accumulator). Instead of issuing a recall for this hazardous defect, Toyota opted to offer "Customer Support Program ZKC". The malfunction that manifested my vehicle is not eligible for this program. Toyota should issue a proper recall to address this safety hazard.

• SERVICE BRAKES

  1. When braking vehicle accelerates for 1 to 2 seconds. 2. I believe safety is at risk for driver, passengers or people close to accelerating car. 3. This has not been confirmed with dealer. 4. Multiple inspections but not for this problem. 5. No warning has ever appeared on any visible car system. Problem has existed for over one year. 2010 Toyota Highlander Platinum Hybrid 4WD

• SERVICE BRAKES

  The brake actuator (4405048320) and brake booster pump (4707048020) malfunctioned. The ABS warning came on the display, as well as a warning saying “Brake Malfunction: pull over car immediately.” The traction control light, ABS light, warning light, and parking brake light also came on. The computer code was C1391. This controls the brakes and anti-lock brake system. This is a serious and known safety issue. It is well-documented online, and in 2019 Toyota acknowledged this widespread issue with a Customer Support Program ZKC. However, this program only applied for a limited time, and since then more vehicles have had this same issue with faulty parts. Even vehicles under 150,000 miles no longer qualify for free replacement despite this being a known and widespread issue.

• SERVICE BRAKES

  My issue is not that I got a brake warning light (see attached image). My issue is that Toyota knows that this is an issue and will only fix it if you experience the issue before 12/30/2020 or at less than 150,000 miles. It is irresponsible of Toyota to know this is an issue, especially regarding the vehicle brakes (see screenshots of the letter from Toyota).

• STEERING

  There is a clunk noise in the steering column On bumpy roads

• SERVICE BRAKES

  Driving down the highway the abs srs air bag lights and the warning triangle all came on and then shortly after that a loud continuous beeping sound started and when my wife tried to pull over she realized she really had to cram on the brakes to get the car to stop... this scared the daylights out of my wife and thank god we didn't get in wreck!! But I dont understand why this is not a recall problem after all the other people I have read about with the same problem with the abs accumulator bleeding off pressure causing the pump motor to run abnormally long and in our case constantly to the point of no being burnt up and needing to replace.. my wife is the second owner of this car and we have had it since 2015... how is the window switch MORE OF AA CONCERN THAN FAULTY ABS ACCUMULATORS???