2017 Tesla Model 3

2017 Tesla Model 3 recalls (15)

• ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

  Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

• ELECTRICAL SYSTEM:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.

• ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK

  Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.

  Remedy: Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.

• FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA

  Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.

  Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.

• ELECTRICAL SYSTEM:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.

• BACK OVER PREVENTION:DISPLAY FUNCTION

  Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.

• ELECTRICAL SYSTEM:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.

• VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

  Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.

• SEAT BELTS:REAR/OTHER:ANCHORAGE

  Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.

  Remedy: Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.

• STEERING:AUTOMATED/ADAPTIVE STEERING

  Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge.  Owner notification letters were mailed April 15, 2023.  Owners may contact Tesla customer service at 1-877-798-3752.  Tesla's number for this recall is SB-23-00-001.

• ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE

  Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

• ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

  Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

• SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

  Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

• TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

  Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

  Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

• BACK OVER PREVENTION:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Remedy: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters are expected to be mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.

2017 Tesla Model 3 safety ratings

Source: NHTSA NCAP ratings.

2017 Tesla Model 3 owner complaints (15)

• AIR BAGS,SEAT BELTS,SEATS

  My Tesla repeatedly displayed a “Passenger Safety Restraint” warning related to the front passenger restraint/airbag system. Tesla Service Center in Los Gatos, California attempted multiple repairs over several visits. The first repair identified a pinched and improperly routed passenger seat harness associated with the restraint system. Tesla stated the issue was repaired and tested. The warning later returned. Tesla then replaced the front right seat harness assembly and lap pretensioner. The warning later returned again. Tesla subsequently proposed and/or performed additional repairs involving the passenger airbag, Occupant Classification System (OCS), occupancy sensor components, and additional seat harness components at significant customer expense. Despite multiple repair attempts and approximately $2,100 in repair costs, the same safety restraint warning still exists today. Because this issue involves the Supplemental Restraint System (SRS), airbags, seatbelt pretensioners, and occupant classification systems, I am concerned the passenger restraint system may not function properly during a collision.

• VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,VISIBILITY/WIPER

  I am writing to file a formal safety complaint against Tesla, Inc. regarding a software update failure that has disabled legally required vehicle functions on my Tesla for over two years. For more than 26 months, my vehicle has been unable to complete a software update through Tesla's over-the-air (OTA) update system. As a direct result of this failure, my vehicle's display screen does not function for the first several minutes of every drive. This prevents me from accessing my speedometer, turn signals, and other legally required safety features, rendering the vehicle non-compliant with federal and state motor vehicle safety standards during this period. I have made multiple documented attempts to resolve this issue through Tesla's customer support channels over the course of these two years. Despite these efforts, the issue remains unresolved. Tesla has now informed me that resolving the defect will require a paid service visit — despite the fact that the failure originates within Tesla's own software update infrastructure, not from any action or negligence on my part. I am requesting that NHTSA investigate this matter on the following grounds: 1. The software defect disables legally required vehicle safety functions, including the speedometer, turn signals, hazard lights, and more. 2. The defect has persisted for over two years despite repeated good-faith efforts by the vehicle owner to resolve it through the manufacturer. 3. Tesla's OTA update system is manufacturer-controlled infrastructure. A failure within that system constitutes a manufacturer defect, not a maintenance issue. 4. Tesla is requiring payment from the consumer to correct a defect in their own systems. I believe this issue may not be isolated to my vehicle and could affect other Tesla owners experiencing similar OTA update failures. I respectfully request that NHTSA investigate whether a broader safety defect exists and whether a recall or corrective action is warranted.

• AIR BAGS,SEAT BELTS

  I received an error about the occupant classification system and a safety restraint fault. These are due to known manufacturing defects. Addressing these concerns was expensive and also required a replacement of the front passenger airbag.

• ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  En primer lugar decir que el VIN utilizado es completamente aleatorio. Esta notificación está dirigida para todos los fabricantes de vehículos eléctricos y fabricantes de baterías. Actualmente los diferentes medios de comunicación y redes sociales no paran de reportar incendios en las baterías de los vehículos eléctricos, con el peligro que esto representa para personas y bienes colindantes. Estos incendios están producidos en gran medida por la deformación que sufren las baterías a lo largo de su vida útil, con las cargas y descargas de las baterías, estas empiezan a hincharse, deformarse hasta que llega a un punto donde las celdas que componen la batería entran en cortocircuito produciendo los incendios ya mencionados. Existe un sistema ya patentado para controlar la deformación de las celdas que componen una batería, una vez que el sistema detecta el hinchado o deformación en las celdas que componen una batería, este puede detener la carga, carga por regeneración y impedir el siguiente arranque del vehículo poniéndolo en modo seguro. Adjunto presentación del sistema mencionado en el siguiente enlace: [XXX] Saludos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• AIR BAGS,SEAT BELTS,SEATS

  Hello. I am following up with the previous safety report I submitted for my vehicle. I just received an updated repair estimate citing the parts that will need replaced (pdf attached). I also confirmed with the service advisor that the functionality of the safety restraint system may be impacted by this issue, however, Tesla still wants to charge drivers $1,300 for this repair.

• AIR BAGS,SEAT BELTS,SEATS

  There is a warning on my car saying “front passenger safety restraint system fault”. The Tesla service center says the fix requires an air bag replacement and to replace the seat sensor. Does this not impact the safety of the passenger? This is the second model 3 I’ve owned that continuously has this fault. I feel like this model should be recalled since it is such a widespread issue. I dealt with this warning light for 2-3 years because Tesla wants to charge >$1,000 for the replacement of these parts. I’m definitely not the only one. There are plenty of complaints online and most people never get it fixed if the vehicle is out of warranty. On the other hand, some people try to fix the problem themselves which could create a worse problem for the safety restraints system.

• UNKNOWN OR OTHER

  I purchased a new 2017 Tesla model 3 in late 2017, drove it 135k miles and suddenly had issues with the battery cooling fan staying on all the time and the interior cooling not working. The Tesla service center found the condenser completely blocked with road debris. This was possible because of a design flaw in the condenser being horizontal and receiving unfiltered air directly scooped from the vent below the grill of the car. This design flaw is present in all model 3 and model Y as I can see but, the amount of debris scooped depends on many factors such as mileage, geography, highway vs local, etc. The result was damage costing $4k to repair and no way of preventing the design flaw from causing another failure in the future.

• AIR BAGS,SEAT BELTS,SEATS

  My car has been having this issue since it was purchased in 2018. An alert appears on the screen which says, "Front Passenger Safety Restraint System Fault/Service is Required." I had the car serviced four times by Tesla under warranty. It has now appeared a fifth time and Tesla says the airbags need to be replaced for over $1,600. The prior repairs included replacing wiring harnesses and occupancy sensor.

• STEERING,UNKNOWN OR OTHER,LANE DEPARTURE

  I had just finished Supercharging my vehicle from 50% to 80% and when I entered the car to drive home two warnings showed up 1. Steering assist was reduced and it might be more difficult to drive; and 2. Lane departure avoidance warning was not working. I did a hard reset twice - (foot on the brake while pressing the two steering wheel 'wheels') and began driving the 10-15 minute home. After an incredibly scary and difficult drive down a circular driveway, and great difficulty turning the wheel to make a right turn in one try, I picked the straightest route to my home - stopping one more time to hard reset. Again nothing! Luckily there was no traffic but I had to make 9 ninety degree turns to get there. I got home - taking 4 tries to maneuver the car into my driveway and garage. I left the car in the garage. Tesla service was closed for the weekend so I arranged for a tow on Monday. The next (Sunday) morning I did another reset and this time the steering assist worked, and I have to assume the lane departure avoidance was working as well because I only drove around the block and put it back in the garage. I understand other models of Tesla have been recalled for this very issue and I'm wondering why the Model 3 was not recalled as well since the software is the same is it not? I don't know if there was something wrong with the Supercharger that created the problem.

• FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  Within a week of posting a complaint here about phantom braking while in autopilot, my autopilot was disabled. Does the NHTSA share VIN numbers with the manufacturer? Because that sure felt like retaliation by Tesla

• VISIBILITY/WIPER

  Back windshield spontaneously cracked from the heat.

• AIR BAGS,SEATS

  Safety Restraint System Fault in front passenger seat alert. Appears to be a common occurrence in Tesla Model 3 cars. Not covered under warranty to due to only 50k mile coverage for safety system, but the failure seems quite common. Required a replacement seat and replacement airbag. Many users reporting the same issue in the car.

• VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  Feb 25 around 4pm PT we were driving north on US Hwy 101 using the basic cruise control feature of our Model 3. Based on our settings I believe this would be considered adaptive cruise control, but I'm not sure. Enhanced Auto-Pilot was not in use. On a largely open highway, in particular with no one in front of us, and thankfully, no one close behind us, the car suddenly started to lose speed, not brake, just lose speed. I pressed the right-hand button on the steering wheel and called out "report bug" so there should be an incident record with Tesla I believe. After letting it slow a bit, I pressed the accelerator to resume and it resumed speed ok. I have used the "report bug" several times on this issue so there should be records of other incidents. Feb. 26, around noon. Traveling on Central Expwy at 55, the car suddenly slowed to about 25 in the space of a few seconds before re-accelerating. No visible object to cause this. Thankfully, no one behind me which is why I let it drop speed to see what it would do. Again, this was using CC, not EAP. This first happened on Jan 14, '22 using cc on s-bd US 101. I have video of this, but it's 19MB, so can't upload. I took to Tesla service and they concluded it was moisture obstructing camera view. Made no sense then as you would it expect to occur constantly, not intermittently. Presumably if this was a vacuum issue, they would have checked that. I think the 3 works CC by wire.

• FORWARD COLLISION AVOIDANCE

  The vehicle frequently applies emergency braking when approaching overpasses at night while driving on highways at night at normal speeds. This happens about once per 100 miles or so.

• SEAT BELTS,SERVICE BRAKES

  My tesla model 3 , parking break do not release. so i can not go front or back!!! i thing they had recall about that long time ago. it happend every month once. you get stuck for 2 hrs or so and then it get atomatically release!!!