2011 Mazda CX-9

2011 Mazda CX-9 recalls (4)

• AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  Mazda North American Operations (Mazda) is recalling certain 2014-2015 Mazda CX-9 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, unless covered in "Zone A," Mazda is recalling certain 2011-2013 Mazda6, 2011-2012 CX-7, and 2011-2015 CX-9 sold, or ever registered in the states of Arizona, Arkansas, Delaware, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, West Virginia and the District of Columbia, or "Zone B." Additionally, unless covered in Zone A or Zone B, Mazda is recalling certain 2010-2013 Mazda6, 2010-2012 CX-7, and 2010-2015 CX-9 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

  Remedy: Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began November 9, 2018. Owners may contact Mazda customer service at 1-800-222-5500, Option 4. Mazda's number for this recall is 1317F.

• AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  Mazda North American Operations (Mazda) is recalling certain 2007-2012 CX-7, CX-9, and 2009-2012 Maza6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

  Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 1317F. Note: This recall supersedes recalls 16V356 and 17V012.

• AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

  Mazda North America Operations (Mazda) is recalling certain 2009-2011 Mazda6, and 2007-2011 CX-7 and CX-9 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

  Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the passenger frontal air bag inflator with an alternate inflator, free of charge. The recall began on August 30, 2017. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 1317F. Note: This recall supersedes recall 16V356 and all vehicles that were not remedied under that campaign are now covered by this one.

• SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

  Mazda North American Operations (Mazda) is recalling certain model year 2007-2014 CX-9 vehicles manufactured October 24, 2006, to December 28, 2013. The affected vehicles have front suspension ball joints that may corrode from water leaking into the fitting.

  Remedy: Mazda will notify owners, and dealers will replace both the left and right lower control arms, free of charge. The recall began on September 14, 2015. The recall will begin with model year 2007-2009 vehicles registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington D.C., West Virginia, and Wisconsin. The second phase will be for model year 2010-2014 vehicles in the same states. Finally, all remaining vehicles will be remedied. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 8515G.

2011 Mazda CX-9 safety ratings

Source: NHTSA NCAP ratings.

2011 Mazda CX-9 owner complaints (15)

• SUSPENSION,POWER TRAIN

  The front driver-side lower ball joint suffered a catastrophic structural failure and sheared completely apart while moving. This vehicle was previously serviced under Safety Recall Campaign 15V451000 / Mazda Recall 8515G for this exact defect. The recall remedy part failed a second time, collapsing the front wheel assembly, ripping the CV axle completely out of the transmission casing, causing a hazardous transmission fluid spill, and leaving the vehicle stranded and immobilized in the middle of a live roadway in the dark

• AIR BAGS,VEHICLE SPEED CONTROL

  The contact owns a 2011 Mazda CX-9. The contact stated that while attempting to park the vehicle at a slow speed in the driveway, the vehicle suddenly experienced unintended acceleration, lurched forward, and crashed into a tree before coming to a stop. The contact was unable to stop the vehicle during the sudden unintended acceleration. During the failure the vehicle sustained front end damages, but no air bags had deployed. No injuries were reported. The cause of the failure was not yet determined. The contact stated that twice in the day before the unintended acceleration, the vehicle jerked forward in traffic however, the contact attributed the issue to the brake pedal not being firmly depressed or the clutch not properly engaged while shifting gear. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet contacted. The failure mileage was 173,000.

• AIR BAGS

  While driving the side airbags exploded and I had to stop in the middle of the street, get vehicle towed to mazda dealer in Alpharetta, GA Now, im without a vehicle. What do I do now?

• SUSPENSION,STRUCTURE

  The contact owns a 2011 Mazda CX-9. The contact stated that while driving at an undisclosed speed and making a turn, the contact lost control of the vehicle, and the front driver's side suspension lowered to the ground. The vehicle was towed to an independent mechanic, who determined that the subframe was severely rusted, causing the control arm to detach. The contact was informed that the subframe needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.

• POWER TRAIN

  I had an issue with the AWD not engaging and the 4x4 light illuminating when driving on snow and ice. No indicators when driving under normal conditions. I had no traction and had difficulty maintaining control of the vehicle while driving at speeds less than 25 mph. I had difficulty gettting momentum from a stop as the tires were spinning and engaging tracion. I took the car into a Mazda dealership for a full circle inspection and found that the 4x4 light was illuminating due to worn-out splines connecting the transfer case. The technician was able to spin the driveshaft, indicating the splines are damaged and need to be replaced. Recommendations were to replace the transmission and transfer case with a repair estimate of $5469.61. Additionally, the technician observed some seeping of oil coming from the tiing cover and reccommends re-sealing it as well as replacing the water pump ( another known failure issue in which Mazda is aware of). Cost estimate of $4319.78. The technician also observed a crack in the right rear differential mount with a repair cost of $442.10. In short, Mazda knew about all these problems. They issued a warrenty extention from my research back in 2014 but never issued any recalls. In short, I didn't own this vehicle in 2014, I purchased in 2016. I was never aware of any warrenty extentions to include these issues and if I was aware, I would have had the services done for repairs. My safety as well as my family's and others are at risk if I lose control of the vehicle due to the AWD not engaging when needed.

• SERVICE BRAKES

  Brake booster failure. The power assisted braking has stopped working. There are no leaking vacuum hoses and the check valve is working. The brake pedal travels to the floorboard.

• ENGINE

  Driving kids to school a few months ago. Car started to smell like burning rubber. I thought it was the garbage truck ahead of us. As we turned the corner 2 blocks later, the car dead stopped and we all went flying forward. It jerked so hard, we are lucky our necks didn't snap. I put the car in park and turned it off. I waited a few minutes as I was too worked up, and started the car again. We got about 50ft before a very loud noise began, almost as if something was dragging underneath. I stopped, and had it towed home. I then had it towed to mechanic. They said bad TRANSFER CASE & DRIVE SHAFT. - TRANS PAN GASKET. I am a single mom with no money to afford to have it fixed in fear of it going bad again. They quoted me 3,500 here in PA.

• SERVICE BRAKES

  The contact owns a 2011 Mazda CX-9. The contact stated while driving 20 MPH, there was an abnormal sound coming from the brakes. The contact stated that the brake pedal was firm and difficult to depress while attempting to stop the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 67,000.

• SERVICE BRAKES

  Braking trouble recent in weeks in 2011 Mazda CX-9 vehicle. Had mechanic (Euro Motorsports in Chagrin Falls OH) check it out. Turned out to be a faulty Brake Booster. Mechanic test drove car; braking failed and he almost rear-ended another vehicle. He found on line a Mazda service notice dating from April 4, 2014 called SSP93. Mazda issued an extended warranty of 7 years or 90,000 miles, whichever came first, to have defective part replaced by an improved part. But we were never informed by Mazda of Bedford, where we bought the vehicle. Currently, our vehicle has about 83,000 miles. Never knew there was a problem until recent trouble with the braking. There are thousands of CX-5, Cx-7, and Cx-9 vehicles in operation in U.S. right now; probably many owners have no idea there is a brake defect in their vehicles that could cause a serious accident, potentially fatal. Mazda should have done a recall in 2014, not an extended warranty. Although Brake Boosters are supposedly good for at least 150,000 miles of driving, our brake failure at around 83,000 miles proves otherwise. NHTSA should order Mazda to recall all vehicles with the defective brake part and replace them at Mazda's expense, probably hundreds of dollars each time. We do not want to have our brake booster replaced by our regular Euro Motosports mechanics because a recall must typically be repaired by the dealer. We already filed a complaint with State of Ohio Attorney General's office, but their people say the complaint must first go through BBB. No urgency on their part at all, even when informed potentially fatal flaw in the brakes. To avoid dangerous accidents, NHTSA should act more swiftly. Thanks.

• ELECTRICAL SYSTEM

  The front door windows no longer work. Most recently, the drivers side back door will NOT open. The lock is completely jammed - will not open or shut, which is a safety hazard for my child. The plastic parts in this car are failing and putting my family at risk.

• ENGINE

  Defective water pump located inside the engine that when failure occurs can cause coolant to leak into engine causing complete engine failure. This is a major safety hazard due to the fact that these cars with defective water pumps can break down with very little warning in the middle of a freeway! I have contacted Mazda who refuses to do anything due to it being outside warranty but will not acknowledge the safety concern sudden engine failure can cause on a perfectly maintained car. In California there is currently a lawsuit against Mazda for this issue and hundreds of other Ford and Mazda owners who have been caught in very dangerous situations due to this water pump failure issue. The situation we were involved in could have gone very differently and that was my family in the vehicle that Mazda seems to care about a couple thousand dollars more then the value of life... is just ridiculous! Please do the research yourself so no one has to loose their life over this.

• POWER TRAIN,ENGINE

  When getting off highway engine began to knock. Engine stalled and would not restart. Upon inspection the water pump was found to have failed and leaked engine coolant into oil. This caused engine to have a complete failure. No check engine light illuminated but when car was scanned multiple codes were found. The car was also found to have a bad Transfer Case.

• ENGINE

  The contact owns a 2011 Mazda CX-9. The contact stated while driving 60 mph, upon approaching oncoming traffic, the vehicle unexpectedly shut-off. The contact was able to restart the vehicle and pulled the vehicle off to the shoulder. The contact stated that upon restarting the vehicle, the check engine warning light illuminated. Due to the failure and the warning light, the contact had the vehicle towed to an independent mechanic. Upon inspection of the vehicle, the mechanic informed her that coolant had leaked into the oil cylinder and they referred her to a dealer for assistance. The contact then had the vehicle towed to the dealer where they diagnosed the vehicle with a defective water pump as well as engine failure. The manufacturer was also notified of the failure and stated that the failure was caused due to poor maintenance. No further assistance was provided. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 144,000.

• SERVICE BRAKES

  SIRT: I PURCHASED MY 2011 MAZDA CX 9 FROM MY CLOSE FRIEND [XXX] ON DEC.05 OF 2014! [XXX] HAD NOT BEEN ISSUED A SPECIAL SERVICES PROGRAM ABOUT THE BRAKE BOOSTER! WELL I NEVER RECEIVED THIS INFO EITHER? IN FACT I HAD TWO RECALL THAT WERE TAKEN CARE OF BY THE LOCAL MAZDA DEALER HERE IN THOUSAND OAKS CALIF. THIS KNOWN BRAKE BOOSTER DETONATION HAS BEEN KNOWN BY MAZDA.IOT IS A VERY DANGEROUS CONDITION AND IS NOT TO SAFE TO DRIVE THE CAR AT ALL- I WILL NOT DRIVE THE CAR AND SEETHE ORIGINAL MATTER SHOULD HAVE BEEN LET IT BE KNOWN TO MYSELF AND FEEL THE MATTER SHOULD BE ADDRESSED ASAP BY MAZDA -THANK YOU [XXX] ADDING BACKING -VERY HARD BRAKE - WHEN DRIVING IT HAD TO REALLY STAND HARD ON THE BRAKE TO STOP CAR B! ALL INDICATIONS POINT TO A BRAKE BOOSTER FAILURE ! TO SUMMARIZE IO WAS NEVER NOTIFIED BY MAZDA ABOUT THE SPECIAL SERVICE PROGRAM FOR THE REPAIR OF THIS EXTREMELY UNSAFE BRAKE PROBLEM! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

• STEERING,ENGINE

  WATER PUMP LEAKING IN ENGINE MIXING WITH OIL