2024 Ford Explorer

2024 Ford Explorer recalls (9)

• HYBRID PROPULSION SYSTEM

  Ford Motor Company (Ford) is recalling certain 2024 Ford Explorer vehicles equipped with 3.3L Hybrid engines. The 12-Volt battery cable may chafe against the Belt-integrated Starter Generat (BiSG) and short circuit.

  Remedy: Dealers will install a tie strap between the battery cable and high voltage cable, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S61.

• EQUIPMENT:OTHER:LABELS

  Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

• SEATS:MID/REAR ASSEMBLY

  Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

  Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.

• BACK OVER PREVENTION:SOFTWARE

  Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

  Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

• TRAILER HITCHES

  Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.

  Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

• EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

  Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

  Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in April 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.

• BACK OVER PREVENTION:SOFTWARE

  Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge.Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.

• SEAT BELTS

  Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

  Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

• POWER TRAIN:AUTOMATIC TRANSMISSION

  Ford Motor Company (Ford) is recalling certain 2024 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

  Remedy: Dealers will inspect for park system damage and replace the park system components as necessary, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S39. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 12, 2026.

2024 Ford Explorer safety ratings

Source: NHTSA NCAP ratings.

2024 Ford Explorer owner complaints (15)

• ELECTRICAL SYSTEM

  The center display went blank and a/c controls under it would not work. Stopped vehicle and pushed ignition button to off and waited 1 minute and pushed ignition back to on on and display was still blank. Got to destination and pushed ignition to off. The next day when I got into vehicle and pushed ignition button to on the display worked.

• FORWARD COLLISION AVOIDANCE

  have been getting a warning coming up saying pre-collision sensor not available sensor blocked over 100 times brought it to the dealership and they said that the bracket for the sensor is broken due to road debris, impact or snow and ice buildup with no evidence of any damage

• SEAT BELTS

  During a severe, multi-lane impact crash, the second-row outer seatbelts completely failed to maintain restraint and failed to retract. Both occupants in the second-row outer seating positions (ages 5 and 7) sustained visible seatbelt friction burns on their arms from the initial impact, but immediately following the crash, both seatbelts were found completely broken, with all slack pulled completely out and zero mechanical retraction. Both children were found entirely unbuckled and unrestrained immediately following the impact. This vehicle is a Ford Explorer, and this failure matches the exact criteria of an active manufacturer safety recall noted on my insurance documentation (NHTSA Campaign ID: 26V159000 / Ford Recall No: 26C18) regarding second-row outer seatbelt anchor bolts being improperly secured. The vehicle has been declared a total loss, but the components are preserved and currently available for inspection upon request under a temporary insurance evidence hold. How safety was put at risk: The safety of two young children was severely compromised. Because the second-row seatbelt mechanisms or anchor bolts failed mid-crash, the children were left entirely unrestrained and unbuckled inside a moving, colliding vehicle after the initial impact, vastly increasing their risk of severe secondary impact injuries. Has the problem been confirmed by a dealer/independent center? UNKNOWN. The failure occurred during the crash, and the vehicle was towed directly to a holding lot. Has it been inspected by others? The vehicle has been documented by insurance representatives for valuation purposes, but a dedicated mechanical inspection of the failed seatbelt components has not yet been performed. Were there warning lamps or prior symptoms? NO. There were absolutely no warning lights, messages, loose seatbelt components, or mechanical symptoms prior to the crash. The system appeared to be functioning normally until it failed under the stress of the impact.

• FORWARD COLLISION AVOIDANCE

  pre-collision warning light comes up, saying sensor blocked and sensor is not blocked. Brought it to the local dealership found that the cruise control module bracket is damaged no visible damage or strikes to the bumper dealership says not under warranty, and Ford is aware of a widespread issue with the bracket snapping on the sensor behind the front bumper

• VISIBILITY/WIPER

  Rear windshield wiper doesn't work. Earlier model years have been recalled for wiper motor issues.

• ELECTRICAL SYSTEM,SEATS,ENGINE

  • Driver seat not setting its memory for the driver , and will move on its own and go all the way to dash while setting in it or all the way back . Has happened multiple times and also twice while driving. • Safety at risk could have made me wreck my vehicle if I hadn’t pulled over and the seat stopped what it was doing front and back. • yes , been checked by dealership (4) times in service department. •yes, every code on the dash has appeared and lasted a total 20 minutes and car went into limp mode. Couldn’t turn car on or off. First happen in Dec 2025. There has been multiple issues with this vehicle since I bought it from the first month.

• SEATS

  The headrest on the third row is locked in the upright position and won't fold down. I've looked online and it seems to happen in every ford explorer in the current generation, 2020+. I see hundreds of complaints online. Across the forums and reddit.

• VISIBILITY/WIPER

  Visual blurry defect in windshield glass in driver side

• AIR BAGS

  The contact owns a 2024 Ford Explorer. The contact stated that while driving 65 MPH, the contact struck a deer with the front of the vehicle. There was no property damage reported. The vehicle came to a stop shortly afterwards. The contact stated that the air bags had not deployed. The vehicle was towed to a local dealer. There was no warning light illuminated. The vehicle was not destroyed. No injuries were reported. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

• UNKNOWN OR OTHER

  Deputy was going to an incident and after arrival at the scene the patrol car began to smoke, and flames were seen within the wheel well. Deputy was not in the vehicle when the fire was discovered, and Fire responded and extinguished the flames - but not before major damage to the engine compartment.

• STEERING,SUSPENSION

  Purchased new from dealer. At 3500 miles, noticed rattling and clunking noise under front end, more noticeable at speeds less than 35. Took to dealer who diagnosed as worn struts, saying shocks and struts need to be replaced, but they need to order parts. When asked if safe to drive, was told "yes", but "avoid potholes". Now waiting to hear from dealer when parts come in. They stated it would take 4 to 5 hours to repair/replace.

• SUSPENSION

  The contact owns a 2024 Ford Explorer. The contact stated while parked upon inspecting the vehicle, he noticed the driver's side and passenger side struts failed. The vehicle was taken to a dealer where it was diagnosed that both front struts needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure and offered no assistance. The approximate failure mileage was 11,103.

• STEERING,SUSPENSION

  The contact owns a 2024 Ford Explorer. The contact stated while driving approximately 30-40 MPH in cold weather, the vehicle started making an abnormal clunking and rattling sound near the wheels. The contact was unable to determine the source of the noise. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 24V091000 (SUSPENSION, STEERING). The vehicle was taken to the local dealer, where it was diagnosed that the front struts were worn and needed to be replaced. The dealer recommended that the contact not drive the vehicle. The vehicle was not repaired due to parts being on backorder. The manufacturer was contacted and filed a complaint. The approximate failure mileage was 3,600.

• UNKNOWN OR OTHER

  Inner fender liners are getting rubbed through by the tires creating large holes and exposing wiring harnesses and other components to the tire/wheel well area. We have seen this on about 5-6 of these same vehicles now.

• VISIBILITY/WIPER

  There is a distortion in the front windshield affecting my ability to see the front right corner of my vehicle. I was leaving a restaurant in the dark and the distortion affected the headlights to the point it didn’t appear there were any on the right side of the vehicle. In daylight, that area of the windshield is so distorted I’ve missed vehicles coming from the right and developed it migraines while driving. The defect was reported to the dealership and they reported it to the manufacturer in August, they have been going back and forth since, most recently being denied due to ‘orange peel’. There is not damage to any of the paint, nor has the vehicle been through a car wash or any paint repairs (trim as been replaced by the dealership). The salesman and a number of service techs are able to confirm the distortion is visible to the center of the windshield. The manufacturer has been requested to check it in person but has not followed through. I am hoping to get a windshield repair shop, second automotive dealership, and potentially and officer to take a look at it this week.